JGH台湾久冈电磁阀4WE-10D/E-W220/50-20 10A/B/C/Y/-G24久冈

JGH台湾久冈电磁阀4WE-10D/E-W220/50-20 10A/B/C/Y/-G24久冈

液压油泵的调试及注意事项

一台新的液压系统组装完成后一般都要经过调试好后才能投入工作，今天主要跟大家讲下液压油泵的调试方法与注意要点。 液压油泵安装完成后，必须经过泵的检查，调试，观察泵的工作是否正常，那如何去检查、调试液压泵是否工作正常呢？ 下面一起来看看吧！

(1)检查油泵的旋转方向应与泵体上标牌所指示的方向相符合，不得接反。

(2)用手转动联轴节，应感轻快，受力均匀，以识别泵的安装是否正常。

(3)检查系统中的安全阀是否在调定的许可压力上。

(4)检查液压系统有没有卸荷回路，能否造成满载啓动和停车，以至降低泵的使用寿命，并使电机过载。

(5)油泵首次试车前，应在排油口灌满油液，使泵内有油，以免泵啓动时因干摩擦损坏元件，同时将安全阀打开。

(6)油泵在工作前应进行不少于10min的空负荷运转.检查泵的运转声音是否正常和液流的方向是否正确。如果正常，则可进行带负荷试车。首先进行低负荷运转，将溢流阀的压力调整到2.0MPa以下转动10一15min,检查系统的动作、外洩漏、噪声、温升等是否正常。如果一切正常，可将溢流阀的压力调整至液压系统的安全保护压力，再使液压系统卸荷。若不正常，则查找原因，再做调试和试车，直到油泵正常工作爲止。

电磁换向阀：
4WE-10A/E-G24-20 4WE-10A/E-W110-20 4WE-10A/E-W220-20 4WE-10A/E-W240-20 4WE-10B/E-G24-20 4WE-10B/E-W110-20
4WE-10B/E-W220-20 4WE-10B/E-W240-20 4WE-10C/E-G24-20 4WE-10C/E-W110-20 4WE-10C/E-W220-20 4WE-10C/E-W240-20
4WE-10D/E-G24-20 4WE-10D/E-W110-20 4WE-10D/E-W220-20 4WE-10D/E-W240-20 4WE-10E/E-G12-20 4WE-10E/E-W110-20
4WE-10E/E-W240-20 4WE-10F/E-G12-20 4WE-10F/E-W110-20 4WE-10F/E-W240-20 4WE-10G/E-G12-20 4WE-10G/E-W110-20
4WE-10G/E-W240-20 4WE-10P/E-W240-20 4WE-10V/E-W240-20 4WE-6-A/E-G12-20 4WE-6-A/E-G24-20 4WE-6-A/E-W110-20
4WE-6-A/E-W220-20 4WE-6-A/E-W240-20 4WE-6-AO/E-G12-20 4WE-6-AO/E-G24-20 4WE-6-AO/E-W110-20
4WE-6-AO/E-W220-20 4WE-6-AO/E-W240-20 4WE-6-AOF/E-G12-20 4WE-6-AOF/E-G24-20 4WE-6-AOF/E-W110-20
4WE-6-AOF/E-W220-20 4WE-6-AOF/E-W240-20 4WE-6-B/E-G12-20 4WE-6-B/E-G24-20 4WE-6-B/E-W110-20 4WE-6-B/E-W220-20
4WE-6-B/E-W240-20 4WE-6-BO/E-G12-20 4WE-6-BO/E-G24-20 4WE-6-BO/E-W110-20 4WE-6-BO/E-W220-20
4WE-6-BO/E-W240-20 4WE-6-BOF/E-G12-20 4WE-6-BOF/E-G24-20 4WE-6-BOF/E-W110-20 4WE-6-BOF/E-W220-20
4WE-6-BOF/E-W240-20 4WE-6-C/E-G12-20 4WE-6-C/E-G24-20 4WE-6-C/E-W110-20 4WE-6-C/E-W220-20 4WE-6-C/E-W240-20
4WE-6-CO/E-G12-20 4WE-6-CO/E-G24-20 4WE-6-CO/E-W110-20 4WE-6-CO/E-W220-20 4WE-6-CO/E-W240-20
4WE-6-COF/E-G12-20 4WE-6-COF/E-G24-20 4WE-6-COF/E-W110-20 4WE-6-COF/E-W220-20 4WE-6-COF/E-W240-20
4WE-6-D/E-G12-20 4WE-6-D/E-G24-20 4WE-6-D/E-W110-20 4WE-6-D/E-W220-20 4WE-6-D/E-W240-20 4WE-6-DO/E-G12-20
4WE-6-DO/E-G24-20 4WE-6-DO/E-W110-20 4WE-6-DO/E-W220-20 4WE-6-DO/E-W240-20 4WE-6-DOF/E-G12-20
4WE-6-DOF/E-G24-20 4WE-6-DOF/E-W110-20 4WE-6-DOF/E-W220-20 4WE-6-DOF/E-W240-20 4WE-6-E/E-G12-20
4WE-6-E/E-G24-20 4WE-6-E/E-W110-20 4WE-6-E/E-W220-20 4WE-6-E/E-W240-20 4WE-6-EO/E-G12-20 4WE-6-EO/E-G24-20
4WE-6-EO/E-W110-20 4WE-6-EO/E-W240-20 4WE-6-EOF/E-G12-20 4WE-6-EOF/E-G24-20 4WE-6-EOF/E-W110-20
4WE-6-EOF/E-W220-20 4WE-6-EOF/E-W240-20 4WE-6-F/E-G12-20 4WE-6-F/E-G24-20 4WE-6-F/E-W110-20 4WE-6-F/E-W220-20
4WE-6-F/E-W240-20 4WE-6-FO/E-G12-20 4WE-6-FO/E-G24-20 4WE-6-FO/E-W110-20 4WE-6-FO/E-W220-20
4WE-6-FO/E-W240-20 4WE-6-FOF/E-G12-20 4WE-6-FOF/E-G24-20 4WE-6-FOF/E-W110-20 4WE-6-FOF/E-W220-20
4WE-6-FOF/E-W240-20 4WE-6-G/E-G12-20 4WE-6-G/E-G24-20 4WE-6-G/E-W110-20 4WE-6G/E-W220/50-20 4WE-6-G/E-W220-20
4WE-6-G/E-W240-20 4WE-6-GO/E-G12-20 4WE-6-GO/E-G24-20 4WE-6-GO/E-W110-20 4WE-6-GO/E-W220-20
4WE-6-GO/E-W240-20 4WE-6-GOF/E-G12-20 4WE-6-GOF/E-G24-20 4WE-6-GOF/E-W110-20 4WE-6-GOF/E-W220-20
4WE-6-GOF/E-W240-20 4WE-6-H/E-G12-20 4WE-6-H/E-G24-20 4WE-6-H/E-W110-20 4WE-6-H/E-W220-20 4WE-6-H/E-W240-20
4WE-6-HA/E-W240-20 4WE-6-HO/E-G12-20 4WE-6-HO/E-G24-20 4WE-6-HO/E-W110-20 4WE-6-HO/E-W220-20
4WE-6-HO/E-W240-20 4WE-6-HOF/E-G12-20 4WE-6-HOF/E-G24-20 4WE-6-HOF/E-W110-20 4WE-6-HOF/E-W220-20
4WE-6-HOF/E-W240-20 4WE-6-J/E-G12-20 4WE-6-J/E-G24-20 4WE-6-J/E-W110-20 4WE-6-J/E-W220/50-20 4WE-6-J/E-W220-20
4WE-6-J/E-W240-20 4WE-6-JO/E-G12-20 4WE-6-JO/E-G24-20 4WE-6-JO/E-W110-20 4WE-6-JO/E-W220-20
4WE-6-JO/E-W240-20 4WE-6-JOF/E-G12-20 4WE-6-JOF/E-G24-20 4WE-6-JOF/E-W110-20 4WE-6-JOF/E-W220-20
4WE-6-JOF/E-W240-20 4WE-6-L/E-G12-20 4WE-6-L/E-G24-20 4WE-6-L/E-W110-20 4WE-6-L/E-W220-20 4WE-6-L/E-W240-20
4WE-6-LO/E-G12-20 4WE-6-LO/E-G24-20 4WE-6-LO/E-W110-20 4WE-6-LO/E-W220-20 4WE-6-LO/E-W240-20
4WE-6-LOF/E-G12-20 4WE-6-LOF/E-G24-20 4WE-6-LOF/E-W110-20 4WE-6-LOF/E-W220-20 4WE-6-LOF/E-W240-20
4WE-6-M/E-G12-20 4WE-6-M/E-G24-20 4WE-6-M/E-W110-20 4WE-6-M/E-W220-20 4WE-6-M/E-W240-20 4WE-6-MO/E-G12-20
4WE-6-MO/E-G24-20 4WE-6-MO/E-W110-20 4WE-6-MO/E-W220-20 4WE-6-MO/E-W240-20 4WE-6-MOF/E-G12-20
4WE-6-MOF/E-G24-20 4WE-6-MOF/E-W110-20 4WE-6-MOF/E-W220-20 4WE-6-MOF/E-W240-20 4WE-6-P/E-G12-20
4WE-6-P/E-G24-20 4WE-6-P/E-W110-20 4WE-6-P/E-W220-20 4WE-6-P/E-W240-20 4WE-6-PO/E-G12-20 4WE-6-PO/E-G24-20
4WE-6-PO/E-W110-20 4WE-6-PO/E-W220-20 4WE-6-PO/E-W240-20 4WE-6-POF/E-G12-20 4WE-6-POF/E-G24-20
4WE-6-POF/E-W110-20 4WE-6-POF/E-W220-20 4WE-6-POF/E-W240-20 4WE-6-Q/E-G12-20 4WE-6-Q/E-G24-20
4WE-6-Q/E-W110-20 4WE-6-Q/E-W220-20 4WE-6-Q/E-W240-20 4WE-6-QO/E-G12-20 4WE-6-QO/E-G24-20
4WE-6-QO/E-W110-20 4WE-6-QO/E-W220-20 4WE-6-QO/E-W240-20 4WE-6-R/E-G12-20 4WE-6-R/E-G24-20 4WE-6-R/E-W110-20
4WE-6-R/E-W220-20 4WE-6-R/E-W240-20 4WE-6-RO/E-G12-20 4WE-6-RO/E-G24-20 4WE-6-RO/E-W110-20 4WE-6-RO/E-W220-20
4WE-6-RO/E-W240-20 4WE-6-ROF/E-G12-20 4WE-6-ROF/E-G24-20 4WE-6-ROF/E-W110-20 4WE-6-ROF/E-W220-20
4WE-6-ROF/E-W240-20 4WE-6-T/E-G12-20 4WE-6-T/E-G24-20 4WE-6-T/E-W110-20 4WE-6-T/E-W220-20 4WE-6-T/E-W240-20
4WE-6-TO/E-G12-20 4WE-6-TO/E-G24-20 4WE-6-TO/E-W110-20 4WE-6-TO/E-W220-20 4WE-6-TO/E-W240-20
4WE-6-TOF/E-G12-20 4WE-6-TOF/E-G24-20 4WE-6-TOF/E-W110-20 4WE-6-TOF/E-W220-20 4WE-6-TOF/E-W240-20
4WE-6-U/E-G12-20 4WE-6-U/E-G24-20 4WE-6-U/E-W110-20 4WE-6-U/E-W220-20 4WE-6-U/E-W240-20 4WE-6-UO/E-G12-20
4WE-6-UO/E-G24-20 4WE-6-UO/E-W110-20 4WE-6-UO/E-W220-20 4WE-6-UO/E-W240-20 4WE-6-UOF/E-G12-20
4WE-6-UOF/E-G24-20 4WE-6-UOF/E-W110-20 4WE-6-UOF/E-W220-20 4WE-6-UOF/E-W240-20 4WE-6-V/E-G12-20
4WE-6-V/E-G24-20 4WE-6-V/E-W110-20 4WE-6-V/E-W220-20 4WE-6-V/E-W240-20 4WE-6-VO/E-G12-20 4WE-6-VO/E-G24-20
4WE-6-VO/E-W110-20 4WE-6-VO/E-W220-20 4WE-6-VO/E-W240-20 4WE-6-VOF/E-G12-20 4WE-6-VOF/E-G24-20
4WE-6-VOF/E-W110-20 4WE-6-VOF/E-W220-20 4WE-6-VOF/E-W240-20 4WE-6-Y/E-G12-20 4WE-6-Y/E-G24-20
4WE-6-Y/E-W110-20 4WE-6-Y/E-W220-20 4WE-6-Y/E-W240-20 4WE-6-YO/E-G12-20 4WE-6-YO/E-G24-20 4WE-6-YO/E-W110-20
4WE-6-YO/E-W220-20 4WE-6-YO/E-W240-20 4WE-6-YOF/E-G12-20 4WE-6-YOF/E-G24-20 4WE-6-YOF/E-W110-20
4WE-6-YOF/E-W220-20 4WE-6-YOF/E-W240-20 4WE-Q-QOF/E-G12-20 4WE-Q-QOF/E-G24-20 4WE-Q-QOF/E-W110-20
4WE-6-QOF/E-W220-20 4WE-Q-QOF/E-W240-20
液控方向阀：
DHG-04-2B2-ET-50-W110-10-AB-K DHG-04-2B2-ET-50-W240-10-AB-K DHG-04-2B3-ET-50-W110-10-AB-K
DHG-04-2B3-ET-50-W240-10-AB-K DHG-04-2D2-ET-50-W110-10-AB-K DHG-04-2D2-ET-50-W240-10-AB-K
DHG-04-2D3-ET-50-W110-10-AB-K DHG-04-2D3-ET-50-W240-10-AB-K DHG-04-3C2-ET-50-W110-10-AB-K
DHG-04-3C2-ET-50-W240-10-AB-K DHG-04-3C3-ET-50-W110-10-AB-K DHG-04-3C3-ET-50-W240-10-AB-K
DHG-04-3C4-ET-50-W110-10-AB-K DHG-04-3C4-ET-50-W240-10-AB-K DHG-04-3C5-ET-50-W110-10-AB-K
DHG-04-3C5-ET-50-W240-10-AB-K DHG-04-3C6-ET-50-W110-10-AB-K DHG-04-3C6-ET-50-W240-10-AB-K 
DHG-04-2B10B DHG-04-2B11A DHG-04-2B11B DHG-04-2B12A DHG-04-2B12B DHG-04-2B2 DHG-04-2B2A
DHG-04-2B2B DHG-04-2B2-ET-50-W110-10-AB-K DHG-04-2B2-ET-50-W240-10-AB-K DHG-04-2B2S DHG-04-2B3
DHG-04-2B3A DHG-04-2B3B DHG-04-2B3-ET-50-W110-10-AB-K DHG-04-2B3-ET-50-W240-10-AB-K DHG-04-2B3S
DHG-04-2B40A DHG-04-2B40B DHG-04-2B4A DHG-04-2B4B DHG-04-2B5A DHG-04-2B5B DHG-04-2B60A DHG-04-2B60B
DHG-04-2B6A DHG-04-2B6B DHG-04-2B8 DHG-04-2B8S DHG-04-2B9A DHG-04-2B9B DHG-04-2D2-ET-50-W110-10-AB-K
DHG-04-2D2-ET-50-W240-10-AB-K DHG-04-2D3-ET-50-W110-10-AB-K DHG-04-2D3-ET-50-W240-10-AB-K
DHG-04-2N2 DHG-04-2N3 DHG-04-3C10-50 DHG-04-3C11-50 DHG-04-3C12-50 DHG-04-3C2 DHG-04-3C2-50
DHG-04-3C2-ET-50-W110-10-AB-K DHG-04-3C2-ET-50-W240-10-AB-K DHG-04-3C3-50 DHG-04-3C3-ET-50-W110-10-AB-K
DHG-04-3C3-ET-50-W240-10-AB-K DHG-04-3C40-50 DHG-04-3C4-50 DHG-04-3C4-ET-50-W110-10-AB-K
DHG-04-3C4-ET-50-W240-10-AB-K DHG-04-3C5-50 DHG-04-3C5-ET-50-W110-10-AB-K DHG-04-3C5-ET-50-W240-10-AB-K
DHG-04-3C60-50 DHG-04-3C6-50 DHG-04-3C6-ET-50-W110-10-AB-K DHG-04-3C6-ET-50-W240-10-AB-K DHG-04-3C9-50
DHG-06-2B10B DHG-06-2B11A DHG-06-2B11B DHG-06-2B12A DHG-06-2B12B DHG-06-2B2 DHG-06-2B2A
DHG-06-2B2B DHG-06-2B2S DHG-06-2B3 DHG-06-2B3A DHG-06-2B3B DHG-06-2B3S DHG-06-2B40A DHG-06-2B40B
DHG-06-2B4A DHG-06-2B4B DHG-06-2B5A DHG-06-2B5B DHG-06-2B60A DHG-06-2B60B DHG-06-2B6A DHG-06-2B6B
DHG-06-2B8 DHG-06-2B8S DHG-06-2B9A DHG-06-2B9B DHG-06-2N2 DHG-06-2N3 DHG-06-3C10-50 DHG-06-3C11-50
DHG-06-3C12-50 DHG-06-3C2-50 DHG-06-3C3-50 DHG-06-3C40-50 DHG-06-3C4-50 DHG-06-3C5-50 DHG-06-3C60-50
DHG-06-3C6-50 DHG-06-3C9-50 DHG-10-2B10B DHG-10-2B11B DHG-10-2B12B DHG-10-2B2B DHG-10-2B3B
DHG-10-2B40B DHG-10-2B4B DHG-10-2B5B DHG-10-2B60B DHG-10-2B6B DHG-10-2B9B DHG-10-2N2 DHG-10-2N3
DHG-10-3C10-50 DHG-10-3C11-50 DHG-10-3C12-50 DHG-10-3C2-50 DHG-10-3C3-50 DHG-10-3C40-50 DHG-10-3C4-50
DHG-10-3C5-50 DHG-10-3C60-50 DHG-10-3C6-50 DHG-10-3C9-50
S-DSHG-10-3H60A220 S-DSHG-10-3H60-A220 S-DSHG-10-3H60-E-D24
抗衡阀：
J-CBEA-1-L J-PBC-A-L J-PBC-B-L J-PBC-D-L J-PBE-A-L J-PBE-B-L J-PBE-D-L J-PBG-A-L J-PBG-B-L J-PBG-D-L
溢流阀：
MRV-02-A-1-A-K MRV-02-A-1-B-K MRV-02-B-1-A-K MRV-02-B-1-B-K MRV-02-B-2-B MRV-02-P-1-A-K MRV-02-P-1-B
MRV-02-P-1-B-K MRV-02-P-3-B MRV-03-A-2-B-K MRV-03-A-2-B-L MRV-03-B-2-B-K MRV-03-B-2-B-L MRV-03-B-3-B
MRV-03-P-2-B-K MRV-03-P-2-B-L MRV-03-P-3-B MSCV-03-A-3-B
电磁控制溢流阀：
SBSG-03-1PN-1-L-30-10 SBSG-03-1PN-1-R-30-10 SBSG-03-1PN-2-L-30-10 SBSG-03-1PN-2-R-30-10 SBSG-03-1PN-3-L-30-10
SBSG-03-1PN-3-R-30-10 SBSG-06-1PN-1-L-30-10 SBSG-06-1PN-1-R-30-10 SBSG-06-1PN-2-L-30-10 SBSG-06-1PN-2-R-30-10
SBSG-06-1PN-3-L-30-10 SBSG-06-1PN-3-R-30-10 SBSG-10-1PN-1-L-30-10 SBSG-10-1PN-1-R-30-10 SBSG-10-1PN-2-L-30-10
SBSG-10-1PN-2-R-30-10 SBSG-10-1PN-3-L-30-10 SBSG-10-1PN-3-R-30-10