液压油泵调试与注意事项 液压油泵安装完成后，必须经过泵的检查，调试，观察泵的工作是否正常。才可以正常投入运作，那如何去检查、调试液压泵是否
工作正常呢？ (1)检查泵的旋转方向应与泵体上标牌所指示的方向相符合，不得接反。 (2)用手转动联轴节，应感轻快，受力均匀，以识别泵的安装是否正常。 (3)检查液压系统中的安全阀是否在调定的许可压力上。 (4)检查液压系统有没有泻荷回路，能否造成满载啓动和停车，以至降低泵的使用寿命，并使电机过载。 大兰液压系统 (5)泵首次试车前，应在排油口灌满油液，使泵内有油，以免泵啓动时因干摩擦损坏元件，同时将安全阀打开。 (6)泵在工作前应进行不少于5min的空负荷运转.检查泵的运转声音是否正常和液流的方向是否正确。如果正常，则可进行带负荷试车。首先进行低负荷运转，将溢流阀的压力调整到2.0MPa以下转动10一15min,检查系统的动作、外洩漏、噪声、温升等是否正常。 如果一切止常，可将溢流阀的压力调整至液压系统的安全保护压力，再使液压系统泻荷。若不正常，则查找原因，再做调试和试车，直到泵正常工作爲止。 台湾KOMPASS康百世V系列变量柱塞泵
V15A1R10X V15A2R10X V15A3R10X V15A4R10X V15A1L10X V15A2L10X V15A3L10X V15A4L10X
V18A1R10X V18A2R10X V18A3R10X V18A4R10X V18A1L10X V18A2L10X V18A3L10X V18A4L10X
V23A1R10X V23A2R10X V23A3R10X V23A4R10X V23A1L10X V23A2L10X V23A3L10X V23A4L10X
V38A1R10X V38A2R10X V38A3R10X V38A4R10X V38A1L10X V38A2L10X V38A3L10X V38A4L10X
V50A1R10X V50A2R10X V50A3R10X V50A4R10X V50A1L10X V50A2L10X V50A3L10X V50A4L10X
V70A1R10X V70A2R10X V70A3R10X V70A4R10X V70A1L10X V70A2L10X V70A3L10X V70A4L10X 台湾KOMPASS康百世AR系列变量柱塞泵
AR16-FR01C AR16-FR01B AR16-LR01C AR16-LR01B AR22-FR01C AR22-FR01B AR22-LR01C
AR22-LR01B AR16-FR01CK AR16-FR01BK AR16-LR01CK AR16-LR01BK AR22-FR01CK AR22-LR01CK
AR22-FR01BS AR22-LR01CS AR22-LR01BS AR22-FR01BK AR22-LR01BK AR16-FR01CS AR16-FR01BS
AR16-LR01CS AR16-LR01BS AR22-FR01CS 台湾KOMPASS康百世定量叶片泵
50T-07-FR 50T-07-LR 50T-12-FR 50T-12-LR 50T-14-FR 50T-14-LR 50T-17-FR 50T-17-LR
50T-20-FR 50T-20-LR 50T-23-FR 50T-23-LR 50T-26-FR 50T-26-LR 50T-30-FR 50T-30-LR
50T-36-FR 50T-36-LR 50T-39-FR 50T-39-LR 150T-48-FR 150T-48-LR 150T-61-FR 150T-61-LR
150T-75-FR 150T-75-LR 150T-94-FR 150T-94-LR 150T-116-FR 150T-116-LR 台湾KOMPASS康百世定量叶片泵
PV2R1-06-FR PV2R1-08-FR PV2R1-10-FR PV2R1-12-FR PV2R1-14-FR PV2R1-17-FR PV2R1-18-FR
PV2R1-23-FR PV2R1-25-FR PV2R1-31-FR PV2R2-33-FR PV2R2-41-FR PV2R2-47-FR PV2R2-53-FR
PV2R2-59-FR PV2R2-65-FR PV2R2-76-FR PV2R2-94-FR PV2R2-116-FR PV2R1-06-LR PV2R1-08-LR
PV2R1-10-LR PV2R1-12-LR PV2R1-14-LR PV2R1-17-LR PV2R1-18-LR PV2R1-23-LR PV2R1-25-LR
PV2R1-31-LR PV2R2-33-LR PV2R2-41-LR PV2R2-47-LR PV2R2-53-LR PV2R2-59-LR PV2R2-65-LR
PV2R2-76-LR PV2R2-94-LR PV2R2-116-LR 中高压变量叶片泵:
VA1-08F-A1 VA1-08F-A2 VA1-08F-A3 VA1-12F-A1 VA1-12F-A2 VA1-12F-A3 VA1-15F-A1 VA1-15F-A2 VA1-15F-A3 VA1-15F-A3
VA1A1-0808F-A1 VA1A1-0808F-A2 VA1A1-0808F-A3 VA1A1-1212F-A1 VA1A1-1212F-A2 VA1A1-1212F-A3 VA1A1-1215F-A1
VA1A1-1215F-A2 VA1A1-1215F-A3
VB1-20F-A1 VB1-20F-A2 VB1-20F-A3 VB1-24F-A1 VB1-24F-A2 VB1-24F-A3
VB1B1-2020F-A1 VB1B1-2020F-A2 VB1B1-2020F-A3 VB1B1-2424F-A1 VB1B1-2424F-A2 VB1B1-2424F-A3
VB3-20F-A1 VB3-20F-A2 VB3-20F-A3 VB3-20F-A4
VC1-26F-A1 VC1-26F-A2 VC1-26F-A3
VD1-25F-A1 VD1-25F-A2 VD1-25F-A3 VD1-30F-A1 VD1-30F-A2 VD1-30F-A3
VD1D1-2525F-A1 VD1D1-2525F-A2 VD1D1-2525F-A3 VD1D1-3030F-A1 VD1D1-3030F-A2 VD1D1-3030F-A3
VD2-20F-A2 VD2-20F-A3 VD2-20F-A4 VD2-25F-A2 VD2-25F-A3 VD2-25F-A4 VD2-30F-A2 VD2-30F-A3 VD2-30F-A4
VD3-25F-A1 VD3-25F-A2 VD3-25F-A3 VD3-25F-A4 VD3-30F-A1 VD3-30F-A2 VD3-30F-A3 VD3-30F-A4
VE1-40F-A1 VE1-40F-A2 VE1-40F-A3 VE1-45F-A1 VE1-45F-A2 VE1-45F-A3
VE1E1-4040F-A1 VE1E1-4040F-A2 VE1E1-4040F-A3 VE1E1-4545F-A1 VE1E1-4545F-A2 VE1E1-4545F-A3
VE2-40F-A2 VE2-40F-A3 VE2-40F-A4
VE3-40F-A1 VE3-40F-A2 VE3-40F-A3 VE3-40F-A4
VF2-54F-A2 VF2-54F-A3 VF2-54F-A4
VF3-54F-A1 VF3-54F-A2 VF3-54F-A3 VF3-54F-A4
VK2-70F-A2 VK2-70F-A3 VK2-70F-A4 VK2-86F-A2 VK2-86F-A3 VK2-86F-A4
VK3-70F-A1 VK3-70F-A2 VK3-70F-A3 VK3-70F-A4 VK3-86F-A1 VK3-86F-A2 VK3-86F-A3 VK3-86F-A4 VQ15-08-FR VQ15-11-FR VQ15-14-FR VQ15-17-FR VQ15-19-FR VQ15-23-FR VQ15-26-FR
VQ15-31-FR VQ25-18-FR VQ25-22-FR VQ25-26-FR VQ25-32-FR VQ25-38-FR VQ25-43-FR
VQ25-52-FR VQ25-60-FR VQ25-65-FR VQ25-75-FR VQ35-60-FR VQ35-66-FR VQ35-76-FR
VQ35-82-FR VQ35-88-FR VQ35-94-FR VQ35-108-FR VQ35-116-FR VQ35-125-FR VQ45-136-FR
VQ45-156-FR VQ45-189-FR VQ45-216-FR VQ45-237-FR VQ215-22-11-FR VQ315-52-23-FR
VQ225-18-26-FR VQ325-108-60-FR VQ425-136-65-FR SVQ215-32-08-FR SVQ435-156-76-FR
PHB19AR-F-11 PHB22AR-F-11 PHB25AR-F-11 PHB28AR-F-11 PHB31AR-F-11 PHB36AR-F-11
VOP-203-A1-F-RV VOP-204-A1-F-RV VOP-206-A1-F-RV VOP-208-A1-F-RV VOP-210-A1-F-RV
VOP-212-A1-F-RV VOP-216-A1-F-RV VOP-220-A1-F-RV VOP-203-A2-F-RV VOP-204-A2-F-RV
VOP-206-A2-F-RV VOP-208-A2-F-RV VOP-210-A2-F-RV VOP-212-A2-F-RV VOP-216-A2-F-RV
VOP-220-A2-F-RVVOP-203-A3-F-RVVOP-204-A3-F-RVVOP-206-A3-F-RVVOP-208-A3-F-RV
VOP-210-A3-F-RVVOP-212-A3-F-RVVOP-216-A3-F-RVVOP-220-A3-F-RVPHB40AR-F-11
高压变量柱塞泵:
PVS08,PVS16,PVS22,PVS36,PVS46,PVS70,PVS100.
PVS08-A4-F-R,PVS08-A3-F-R,PVS08-A2-F-R,PVS08-A1-F-R,PVS08-A0-F-R.
PVS16-A4-F-R,PVS16-A3-F-R,PVS16-A2-F-R,PVS16-A1-F-R,PVS16-A0-F-R.
PVS22-A4-F-R,PVS22-A3-F-R,PVS22-A2-F-R,PVS22-A1-F-R,PVS22-A0-F-R.
PVS36-A4-F-R,PVS36-A3-F-R,PVS36-A2-F-R,PVS36-A1-F-R,PVS36-A0-F-R.
PVS46-A4-F-R,PVS46-A3-F-R,PVS46-A2-F-R,PVS46-A1-F-R,PVS46-A0-F-R.
PVS70-A4-F-R,PVS70-A3-F-R,PVS70-A2-F-R,PVS70-A1-F-R,PVS70-A0-F-R.
PVS100-A4-F-R,PVS100-A3-F-R,PVS100-A2-F-R,PVS100-A1-F-R,PVS100-A0-F-R KOMPASS电磁阀部分型号： D5-02-2B2B，、D5-02-3C2，、D5-02-3C4，、D4-02-3C4,、D4-03-2B2.、 台湾KOMPASS液控单向阀
MPA-04B 、MPA-03A 、MPA-03B 、MPA-03C、MPA-04A 、MPA-04B 、MPA-04C、MPA-06A 、MPA-06B 、MPA-06A、 台湾KOMPASS减压阀：
MRP-02A-H 、MRP-02B-H 、MRP-02C-H 、MRP-02H-H、MRP-03-A-H 、MRP-03-B-H 、MRP-03-C-H 、MRP-03-H-H、、MRB-06-A-H 、MRB-06-B-H 、MRRP-02-B-M MRRP-03-B-M MRRP-02-B-H MRRP-03-B-H MRRP-02-C-M MRRP-03-C-M
MRRP-02-C-H MRRP-03-C-H MRRP-02-H-M MRRP-03-H-M MRRP-02-H-H MRRP-03-H-H
MRRA-02-B-M MRRA-03-B-M MRRA-02-B-H MRRA-03-B-H MRRA-02-C-M MRRA-03-C-M
MRRA-02-C-H MRRA-03-C-H MRRA-02-H-M MRRA-03-H-M MRRA-02-H-H MRRA-03-H-H
MRRB-02-B-M MRRB-03-B-M MRRB-02-B-H MRRB-03-B-H MRRB-02-C-M MRRB-03-C-M
MRRB-02-C-H MRRB-03-C-H MRRB-02-H-M MRRB-03-H-M MRRB-02-H-H MRRB-03-H-H
MQP-02-B MQP-02-C MQP-02-H MQP-03-BMQP-03-C MQP-03-HMQP-02-B-P MQP-02-C-P
MQP-02-H-P MQP-03-B-P MQP-03-C-P MQP-03-H-P MHB-06-B MHB-06-H
MHB-06-B-P MHB-06-H-P MHB-04-B-P MHB-04-H-P MHB-04-B MHB-04-H
MHA-02-B MHA-03-B MHA-02-H MHA-03-H MHB-02-B MHB-03-B MHB-02-H MHB-03-H
MHB-04-B MHB-04-H MHA-02-B-P MHA-03-B-P MHA-02-H-P MHA-03-H-P
MHB-02-B-P MHB-03-B-P MHB-02-H-P MHB-03-H-P MTP-02 MTP-03MTT-02 MTT-03
MSP-02 MSP-03 MSA-02-X MSA-03-X MSA-04-X MSA-06-X MSA-02-Y MSA-03-Y
MSA-04-Y MSA-06-Y MSB-02-X MSB-03-X MSB-04-X MSB-06-X MSB-02-Y MSB-03-Y
MSB-04-Y MSB-06-Y MSW-02-X MSW-03-X MSW-04-X MSW-06-X MSW-02-Y MSW-03-Y 台湾KOMPASS叠加式减压阀、MRB-03-A-H 、MRB-03-B-H 、MRB-03-C-H 、MRB-03-H-H、 手动换向阀
DMT-03-W-2B2 DMT-04-W-2B2 DMT-06-W-2B2 DMT-10-W-2B2 DMG-02-W-2B2 DMG-03-W-2B2
DMT-03-W-3C2 DMT-04-W-3C2 DMT-06-W-3C2 DMT-10-W-3C2 DMG-02-W-3C2 DMG-03-W-3C2
DMT-03-W-3C3 DMT-04-W-3C3 DMT-06-W-3C3 DMT-10-W-3C3 DMG-02-W-3C3 DMG-03-W-3C3
DMT-03-W-3C4 DMT-04-W-3C4 DMT-06-W-3C4 DMT-10-W-3C4 DMG-02-W-3C4 DMG-03-W-3C4
DMT-03-W-3C6 DMT-04-W-3C6 DMT-06-W-3C6 DMT-10-W-3C6 DMG-02-W-3C6 DMG-03-W-3C6 背压阀
MCAG-06,MCAG-06-B,MCAG-06-C,MCAG-06-H,
MCAG-10,MCAG-10-B,MCAG-10-C,MCAG-10-H. 单向阀
CRG-03-A1 CRG-06-A1 CRG-10-A1 CIT-03-A1 CIT-04-A1 CIT-06-A1 CIT-08-A1 CIT-10-A1 CIT-12-A1
CRG-03-A2 CRG-06-A2 CRG-10-A2 CIT-03-A2 CIT-04-A2 CIT-06-A2 CIT-08-A2 CIT-10-A2 CIT-12-A2
CRNG-03-A1 CRNG-06-A1 CRNG-10-A1 CRNG-03-A2 CRNG-06-A2 CRNG-10-A2 CIT-16-A1 CIT-16-A2 叠加式单向阀
MCP-02-B MCP-03-B MCP-04-B MCP-06-B MCA-02-B MCA-03-B MCB-02-B MCB-03-B
MCT-02-B MCT-03-B MCT-04-B MCT-06-B MCW-02-B MCW-03-B MCW-03-B MCW-02-B
叠加式液控单向阀
MPW-02-B MPW-03-B MPW-04-B MPW-06-B MPDA-03-B MPDB-03-B MPDW-03-B
MPA-02-B MPA-03-B MPA-04-B MPA-06-B MPB-02-B MPB-03-B MPB-04-B MPB-06-B
MBP-01-B-H MBP-02-B-H MBP-03-B-H MBP-06-B-H MBP-01-B-M MBP-02-B-M
MBP-03-B-M MBP-06-B-M MBA-01-B-H MBA-02-B-H MBA-03-B-H MBA-06-B-H
MBA-01-B-M MBA-02-B-M MBA-03-B-M MBA-06-B-M MBB-01-B-H MBB-02-B-H
MBB-03-B-H MBB-06-B-H MBB-01-B-M MBB-02-B-M MBB-03-B-M MBB-06-B-M
MBW-01-B-H MBW-02-B-H MBW-03-B-H MBW-01-B-M MBW-02-B-M MBW-03-B-M
MBP-01-C-H MBP-02-C-H MBP-03-C-H MBP-06-C-H MBP-01-C-M MBP-02-C-M
MBP-03-C-M MBP-06-C-M MBA-01-C-H MBA-02-C-H MBA-03-C-H MBA-06-C-H
MBA-01-C-M MBA-02-C-M MBA-03-C-M MBA-06-C-M MBB-01-C-H MBB-02-C-H
MBB-03-C-H MBB-06-C-H MBB-01-C-M MBB-02-C-M MBB-03-C-M MBB-06-C-M
MBW-01-C-H MBW-02-C-H MBW-03-C-H MBW-01-C-M MBW-02-C-M MBW-03-C-M
MBP-01-H-H MBP-02-H-H MBP-03-H-H MBP-06-H-H MBP-01-H-M MBP-02-H-M
MBP-03-H-M MBP-06-H-M MBA-01-H-H MBA-02-H-H MBA-03-H-H MBA-06-H-H
MBA-01-H-M MBA-02-H-M MBA-03-H-M MBA-06-H-M MBB-01-H-H MBB-02-H-H
标准型油路块
MMCA-02-3 MMCA-03-3 MMCB-02-3 MMCB-03-3 梭动阀SHT-02
直入式溢流插装阀
CVB-M-50-6-H-D4-A25 CVB-M-40-6-H-D5-A25
CVB-M-16-6-H-D4-A25 CVB-M-25-6-H-D4-A25 CVB-M-32-6-H-D4-A25 CVB-M-40-6-H-D4-A25
CVB-M-16-6-H-D5-A25 CVB-M-25-6-H-D5-A25 CVB-M-32-6-H-D5-A25 CVB-M-40-6-H-D5-A25
电磁换向阀
D5-02-3C2,D5-02-2B2,D5-02-3,D5-02-3C60,D5-02-2D2,
D5-03-3C2,D5-03-2B2,D5-03-3,D5-03-3C60,D5-03-2D2.
D4-02-3C2,D4-02-2B2,D4-02-3,D4-02-3C60,D4-02-2D2,
D4-03-3C2,D4-03-2B2,D4-03-3,D4-03-3C60,D4-03-2D2.
D5-02-2B2B D5-02-2B3B D5-02-2B4B D5-02-2B5B D5-02-2B40B D5-02-2B60B
D5-02-2B2-A25 D5-02-2B2-A15 D5-02-2B2-A35 D5-02-2B2-D1 D5-02-2B2-D2
D5-02-2B3-A25 D5-02-2B3-A15 D5-02-2B3-A35 D5-02-2B3-D1 D5-02-2B3-D2
D5-02-2B8-A25 D5-02-2B8-A15 D5-02-2B8-A35 D5-02-2B8-D1 D5-02-2B8-D2
卸荷溢流阀
BUCG-06-B-G BUCG-06-C-G BUCG-06-H-G
DB系列先导式溢流阀
DB-03-1 DB-03-3 DB-06-1 DB-06-3 DB-10-1 DB-10-3
管式单向节流阀
TVC-02 TVC-03 TVC-04 TVC-06 TVL-03 TVH-03 TVH-04
电磁控制调速阀
THF-06 THF-10 SF-06 SF-10 SDF-06 SDF-10 SFD-10 SD-06 SKF-06
加强型先导式溢流阀
BHG-06-B-G BHG-06-C-G BHG-06-H-G BHG-10-B-G BHG-10-C-G BHG-10-H-G
VOP润滑泵
VOP-203-A2-F-RV VOP-204-A2-F-RV VOP-206-A2-F-RV VOP-208-A2-F-RV VOP-210-A2-F-RV
VOP-212-A2-F-RV VOP-216-A2-F-RV VOP-220-A2-F-RV
HV-03-0-3C2 CPD-03-A1-T-D CPD-04-A1-T-D CPD-06-A1-T-D CPD-10-A1-T-D CPD-16-A1-T-D
机械式换向阀
DCG-02-NC-A DCG-02-NC-B DCG-02-NC-C DCG-02-NO-A DCG-02-NO-B DCG-02-NO-C
DCT-02-NC-A DCT-02-NC-B DCT-02-NC-C DCT-02-NO-A DCT-02-NO-B DCT-02-NO-C 压力继电器部分型号：
JCD-02S JCS-02N JCS-02NL JCS-02NLL
JPS-02HM JPS-02L JPS-02LL
MJCS-02P-N MJCS-02A-N MJCS-02B-N MJCS-02W-N MJCS-02-P-L MJCS-02-A-L MJCS-02-B-L
MJCS-02-W-L MJCS-02P-LL MJCS-02A-LL APSA-150-1 APSA-150-2 APSA-150-3 APSA-150-4 APSA-230-1 APSA-230-2 APSA-230-3
APSA-230-4 APSA-35-1 APSA-35-2 APSA-35-3 APSA-35-4 APSA-420-1 APSA-420-2 APSA-420-3
APSA-420-4 APSA-70-1 APSA-70-2 APSA-70-3 APSA-70-4 APSB-150-1
APSB-150-2 APSB-150-3 APSB-150-4 APSB-230-1 APSB-230-2 APSB-230-3 APSB-230-4 APSB-35-1
APSB-35-2 APSB-35-3 APSB-35-4 APSB-420-1 APSB-420-2 APSB-420-3 APSB-420-4 APSB-70-1
APSB-70-2 APSB-70-3 APSB-70-4 APSC-125-1
APSC-125-2 APSC-125-3 APSC-125-4 APSC-275-1 APSC-275-2 APSC-275-3 APSC-275-4
APSC-400-1 APSC-400-2 APSC-400-3 APSC-400-4 APSC-60-1 APSC-60-2 APSC-60-3 APSC-60-4
APSD-40-1 APSD-40-2 APSD-40-3 APSD-40-4
APSE-125-1 APSE-125-2 APSE-125-3 APSE-125-4 APSE-275-1 APSE-275-2 APSE-275-3
APSE-275-4 APSE-400-1 APSE-400-2 APSE-400-3 APSE-400-4 APSE-60-1 APSE-60-2 APSE-60-3 APSE-60-4
APSF-125-1 APSF-125-2 APSF-125-3 APSF-125-4 APSF-275-1 APSF-275-2 APSF-275-3 APSF-275-4
APSF-400-1 APSF-400-2 APSF-400-3 APSF-400-4 APSF-60-1 APSF-60-2 APSF-60-3 APSF-60-4
APSG-125-1 APSG-125-2 APSG-125-3 APSG-125-4 APSG-275-1 APSG-275-2 APSG-275-3 APSG-275-4
APSG-60-1 APSG-60-2 APSG-60-3 APSG-60-4
APSH-125-1 APSH-125-2 APSH-125-3 APSH-125-4 APSH-275-1 APSH-275-2 APSH-275-3
APSH-275-4 APSH-60-1 APSH-60-2 APSH-60-3 APSH-60-4
| 
