KOMPASS康百世润滑泵VOP-203/208/210/212/216/220-F-RV-A1 A2 A3

KOMPASS康百世润滑泵VOP-203/208/210/212/216/220-F-RV-A1 A2 A3

液压缸推力不足是何原因呢？

液压油缸是液压系统的执行元件，有时候液压油缸会出现推力不足或动作不稳定从而会使力和速度都不能满足工作需要，今天 就给大家分析下其主要原因：

缸内洩露：

洩露的原因：油缸与活塞因磨损而间隙过大，若活塞装上密封圈，则因磨损或密封圈老化而失去密封作用。

清除的措施：更换活塞或密封圈，保持合理的间隙。

若油缸经常使用的隻是某一部分，则局部磨损严重，间隙增大，缸内洩露。此时，可重磨缸径、重配活塞。

油缸内部别劲，动作阻力过大，使油缸的速度随行程位置的不同而变化。

産生这种现象的原因：由于装配质量差说引起。(活塞杆密封压得太紧、活塞杆较长、在滑动部位造成过大的压力)或污物进入油缸的滑动部位 (特别是颗粒状污物)。

若溢流阀进入赃物，则阀芯处于常开状态，油液自动流回油箱，液压油缸内无油液流入。若负荷过大，溢流阀的调整压力虽已已达到最大额定值，但油缸仍得不到连续动作动作所需的力，油缸不动作。若调整压力较低，达不到负荷所需的推力，则表现压力不足，推力不够。这些问题均发生在溢流阀上，故应检查溢流阀。

1.油缸内有空气或油泵供油不足，会使油缸动作不稳定(或动作迟缓)。

消除的办法：排除油缸内的空气或检查油泵。

2.还有一种情况，从压力表上显示的缸内压力足够，但油缸仍推不动。

産生这种现象的原因：一般是活塞侧面与缸盖接触较紧，压力油进不去或有效工作面积太小，不能産生足够推力使油缸动作。

台湾KOMPASS康百世V系列变量柱塞泵
V15A1R10X V15A2R10X V15A3R10X V15A4R10X V15A1L10X V15A2L10X V15A3L10X V15A4L10X
V18A1R10X V18A2R10X V18A3R10X V18A4R10X V18A1L10X V18A2L10X V18A3L10X V18A4L10X
V23A1R10X V23A2R10X V23A3R10X V23A4R10X V23A1L10X V23A2L10X V23A3L10X V23A4L10X
V38A1R10X V38A2R10X V38A3R10X V38A4R10X V38A1L10X V38A2L10X V38A3L10X V38A4L10X
V50A1R10X V50A2R10X V50A3R10X V50A4R10X V50A1L10X V50A2L10X V50A3L10X V50A4L10X
V70A1R10X V70A2R10X V70A3R10X V70A4R10X V70A1L10X V70A2L10X V70A3L10X V70A4L10X

台湾KOMPASS康百世AR系列变量柱塞泵
AR16-FR01C AR16-FR01B AR16-LR01C AR16-LR01B AR22-FR01C AR22-FR01B AR22-LR01C
AR22-LR01B AR16-FR01CK AR16-FR01BK AR16-LR01CK AR16-LR01BK AR22-FR01CK AR22-LR01CK
AR22-FR01BS AR22-LR01CS AR22-LR01BS AR22-FR01BK AR22-LR01BK AR16-FR01CS AR16-FR01BS
AR16-LR01CS AR16-LR01BS AR22-FR01CS

台湾KOMPASS康百世定量叶片泵
50T-07-FR 50T-07-LR 50T-12-FR 50T-12-LR 50T-14-FR 50T-14-LR 50T-17-FR 50T-17-LR
50T-20-FR 50T-20-LR 50T-23-FR 50T-23-LR 50T-26-FR 50T-26-LR 50T-30-FR 50T-30-LR
50T-36-FR 50T-36-LR 50T-39-FR 50T-39-LR 150T-48-FR 150T-48-LR 150T-61-FR 150T-61-LR
150T-75-FR 150T-75-LR 150T-94-FR 150T-94-LR 150T-116-FR 150T-116-LR

台湾KOMPASS康百世定量叶片泵
PV2R1-06-FR PV2R1-08-FR PV2R1-10-FR PV2R1-12-FR PV2R1-14-FR PV2R1-17-FR PV2R1-18-FR
PV2R1-23-FR PV2R1-25-FR PV2R1-31-FR PV2R2-33-FR PV2R2-41-FR PV2R2-47-FR PV2R2-53-FR
PV2R2-59-FR PV2R2-65-FR PV2R2-76-FR PV2R2-94-FR PV2R2-116-FR PV2R1-06-LR PV2R1-08-LR
PV2R1-10-LR PV2R1-12-LR PV2R1-14-LR PV2R1-17-LR PV2R1-18-LR PV2R1-23-LR PV2R1-25-LR
PV2R1-31-LR PV2R2-33-LR PV2R2-41-LR PV2R2-47-LR PV2R2-53-LR PV2R2-59-LR PV2R2-65-LR
PV2R2-76-LR PV2R2-94-LR PV2R2-116-LR

中高压变量叶片泵:
VA1-08F-A1 VA1-08F-A2 VA1-08F-A3 VA1-12F-A1 VA1-12F-A2 VA1-12F-A3 VA1-15F-A1 VA1-15F-A2 VA1-15F-A3 VA1-15F-A3
VA1A1-0808F-A1 VA1A1-0808F-A2 VA1A1-0808F-A3 VA1A1-1212F-A1 VA1A1-1212F-A2 VA1A1-1212F-A3 VA1A1-1215F-A1
VA1A1-1215F-A2 VA1A1-1215F-A3
VB1-20F-A1 VB1-20F-A2 VB1-20F-A3 VB1-24F-A1 VB1-24F-A2 VB1-24F-A3
VB1B1-2020F-A1 VB1B1-2020F-A2 VB1B1-2020F-A3 VB1B1-2424F-A1 VB1B1-2424F-A2 VB1B1-2424F-A3
VB3-20F-A1 VB3-20F-A2 VB3-20F-A3 VB3-20F-A4
VC1-26F-A1 VC1-26F-A2 VC1-26F-A3
VD1-25F-A1 VD1-25F-A2 VD1-25F-A3 VD1-30F-A1 VD1-30F-A2 VD1-30F-A3
VD1D1-2525F-A1 VD1D1-2525F-A2 VD1D1-2525F-A3 VD1D1-3030F-A1 VD1D1-3030F-A2 VD1D1-3030F-A3
VD2-20F-A2 VD2-20F-A3 VD2-20F-A4 VD2-25F-A2 VD2-25F-A3 VD2-25F-A4 VD2-30F-A2 VD2-30F-A3 VD2-30F-A4
VD3-25F-A1 VD3-25F-A2 VD3-25F-A3 VD3-25F-A4 VD3-30F-A1 VD3-30F-A2 VD3-30F-A3 VD3-30F-A4
VE1-40F-A1 VE1-40F-A2 VE1-40F-A3 VE1-45F-A1 VE1-45F-A2 VE1-45F-A3
VE1E1-4040F-A1 VE1E1-4040F-A2 VE1E1-4040F-A3 VE1E1-4545F-A1 VE1E1-4545F-A2 VE1E1-4545F-A3
VE2-40F-A2 VE2-40F-A3 VE2-40F-A4
VE3-40F-A1 VE3-40F-A2 VE3-40F-A3 VE3-40F-A4
VF2-54F-A2 VF2-54F-A3 VF2-54F-A4
VF3-54F-A1 VF3-54F-A2 VF3-54F-A3 VF3-54F-A4
VK2-70F-A2 VK2-70F-A3 VK2-70F-A4 VK2-86F-A2 VK2-86F-A3 VK2-86F-A4
VK3-70F-A1 VK3-70F-A2 VK3-70F-A3 VK3-70F-A4 VK3-86F-A1 VK3-86F-A2 VK3-86F-A3 VK3-86F-A4 

VQ15-08-FR VQ15-11-FR VQ15-14-FR VQ15-17-FR VQ15-19-FR VQ15-23-FR VQ15-26-FR
VQ15-31-FR VQ25-18-FR VQ25-22-FR VQ25-26-FR VQ25-32-FR VQ25-38-FR VQ25-43-FR
VQ25-52-FR VQ25-60-FR VQ25-65-FR VQ25-75-FR VQ35-60-FR VQ35-66-FR VQ35-76-FR
VQ35-82-FR VQ35-88-FR VQ35-94-FR VQ35-108-FR VQ35-116-FR VQ35-125-FR VQ45-136-FR
VQ45-156-FR VQ45-189-FR VQ45-216-FR VQ45-237-FR VQ215-22-11-FR VQ315-52-23-FR
VQ225-18-26-FR VQ325-108-60-FR VQ425-136-65-FR SVQ215-32-08-FR SVQ435-156-76-FR
PHB19AR-F-11 PHB22AR-F-11 PHB25AR-F-11 PHB28AR-F-11 PHB31AR-F-11 PHB36AR-F-11
VOP-203-A1-F-RV VOP-204-A1-F-RV VOP-206-A1-F-RV VOP-208-A1-F-RV VOP-210-A1-F-RV
VOP-212-A1-F-RV VOP-216-A1-F-RV VOP-220-A1-F-RV VOP-203-A2-F-RV VOP-204-A2-F-RV
VOP-206-A2-F-RV VOP-208-A2-F-RV VOP-210-A2-F-RV VOP-212-A2-F-RV VOP-216-A2-F-RV
VOP-220-A2-F-RVVOP-203-A3-F-RVVOP-204-A3-F-RVVOP-206-A3-F-RVVOP-208-A3-F-RV
VOP-210-A3-F-RVVOP-212-A3-F-RVVOP-216-A3-F-RVVOP-220-A3-F-RVPHB40AR-F-11
高压变量柱塞泵:
PVS08,PVS16,PVS22,PVS36,PVS46,PVS70,PVS100.
 PVS08-A4-F-R,PVS08-A3-F-R,PVS08-A2-F-R,PVS08-A1-F-R,PVS08-A0-F-R.
 PVS16-A4-F-R,PVS16-A3-F-R,PVS16-A2-F-R,PVS16-A1-F-R,PVS16-A0-F-R.
 PVS22-A4-F-R,PVS22-A3-F-R,PVS22-A2-F-R,PVS22-A1-F-R,PVS22-A0-F-R.
 PVS36-A4-F-R,PVS36-A3-F-R,PVS36-A2-F-R,PVS36-A1-F-R,PVS36-A0-F-R.
 PVS46-A4-F-R,PVS46-A3-F-R,PVS46-A2-F-R,PVS46-A1-F-R,PVS46-A0-F-R.
 PVS70-A4-F-R,PVS70-A3-F-R,PVS70-A2-F-R,PVS70-A1-F-R,PVS70-A0-F-R.
 PVS100-A4-F-R,PVS100-A3-F-R,PVS100-A2-F-R,PVS100-A1-F-R,PVS100-A0-F-R

KOMPASS电磁阀部分型号：

D5-02-2B2B，、D5-02-3C2，、D5-02-3C4，、D4-02-3C4,、D4-03-2B2.、

台湾KOMPASS液控单向阀
MPA-04B 、MPA-03A   、MPA-03B  、MPA-03C、MPA-04A   、MPA-04B  、MPA-04C、MPA-06A   、MPA-06B  、MPA-06A、

台湾KOMPASS减压阀：
MRP-02A-H 、MRP-02B-H 、MRP-02C-H 、MRP-02H-H、MRP-03-A-H 、MRP-03-B-H 、MRP-03-C-H 、MRP-03-H-H、、MRB-06-A-H 、MRB-06-B-H 、MRRP-02-B-M MRRP-03-B-M MRRP-02-B-H MRRP-03-B-H MRRP-02-C-M MRRP-03-C-M
MRRP-02-C-H MRRP-03-C-H MRRP-02-H-M MRRP-03-H-M MRRP-02-H-H MRRP-03-H-H
MRRA-02-B-M MRRA-03-B-M MRRA-02-B-H MRRA-03-B-H MRRA-02-C-M MRRA-03-C-M
MRRA-02-C-H MRRA-03-C-H MRRA-02-H-M MRRA-03-H-M MRRA-02-H-H MRRA-03-H-H
MRRB-02-B-M MRRB-03-B-M MRRB-02-B-H MRRB-03-B-H MRRB-02-C-M MRRB-03-C-M
MRRB-02-C-H MRRB-03-C-H MRRB-02-H-M MRRB-03-H-M MRRB-02-H-H MRRB-03-H-H
MQP-02-B MQP-02-C MQP-02-H MQP-03-BMQP-03-C MQP-03-HMQP-02-B-P MQP-02-C-P
MQP-02-H-P MQP-03-B-P MQP-03-C-P MQP-03-H-P MHB-06-B MHB-06-H
MHB-06-B-P MHB-06-H-P MHB-04-B-P MHB-04-H-P MHB-04-B MHB-04-H
MHA-02-B MHA-03-B MHA-02-H MHA-03-H MHB-02-B MHB-03-B MHB-02-H MHB-03-H
MHB-04-B MHB-04-H MHA-02-B-P MHA-03-B-P MHA-02-H-P MHA-03-H-P
MHB-02-B-P MHB-03-B-P MHB-02-H-P MHB-03-H-P MTP-02 MTP-03MTT-02 MTT-03
MSP-02 MSP-03  MSA-02-X MSA-03-X MSA-04-X MSA-06-X MSA-02-Y MSA-03-Y
MSA-04-Y MSA-06-Y MSB-02-X MSB-03-X MSB-04-X MSB-06-X MSB-02-Y MSB-03-Y
MSB-04-Y MSB-06-Y MSW-02-X MSW-03-X MSW-04-X MSW-06-X MSW-02-Y MSW-03-Y

台湾KOMPASS叠加式减压阀、MRB-03-A-H 、MRB-03-B-H 、MRB-03-C-H 、MRB-03-H-H、

手动换向阀
DMT-03-W-2B2 DMT-04-W-2B2 DMT-06-W-2B2 DMT-10-W-2B2 DMG-02-W-2B2 DMG-03-W-2B2
DMT-03-W-3C2 DMT-04-W-3C2 DMT-06-W-3C2 DMT-10-W-3C2 DMG-02-W-3C2 DMG-03-W-3C2
DMT-03-W-3C3 DMT-04-W-3C3 DMT-06-W-3C3 DMT-10-W-3C3 DMG-02-W-3C3 DMG-03-W-3C3
DMT-03-W-3C4 DMT-04-W-3C4 DMT-06-W-3C4 DMT-10-W-3C4 DMG-02-W-3C4 DMG-03-W-3C4
DMT-03-W-3C6 DMT-04-W-3C6 DMT-06-W-3C6 DMT-10-W-3C6 DMG-02-W-3C6 DMG-03-W-3C6

背压阀
MCAG-06,MCAG-06-B,MCAG-06-C,MCAG-06-H,
MCAG-10,MCAG-10-B,MCAG-10-C,MCAG-10-H.

单向阀
CRG-03-A1 CRG-06-A1 CRG-10-A1 CIT-03-A1 CIT-04-A1 CIT-06-A1 CIT-08-A1 CIT-10-A1 CIT-12-A1
CRG-03-A2 CRG-06-A2 CRG-10-A2 CIT-03-A2 CIT-04-A2 CIT-06-A2 CIT-08-A2 CIT-10-A2 CIT-12-A2
CRNG-03-A1 CRNG-06-A1 CRNG-10-A1 CRNG-03-A2 CRNG-06-A2 CRNG-10-A2 CIT-16-A1 CIT-16-A2

叠加式单向阀
MCP-02-B MCP-03-B MCP-04-B MCP-06-B MCA-02-B MCA-03-B MCB-02-B MCB-03-B
MCT-02-B MCT-03-B MCT-04-B MCT-06-B MCW-02-B MCW-03-B MCW-03-B MCW-02-B
叠加式液控单向阀
MPW-02-B MPW-03-B MPW-04-B MPW-06-B MPDA-03-B MPDB-03-B MPDW-03-B
MPA-02-B MPA-03-B MPA-04-B MPA-06-B MPB-02-B MPB-03-B MPB-04-B MPB-06-B
MBP-01-B-H MBP-02-B-H MBP-03-B-H MBP-06-B-H MBP-01-B-M MBP-02-B-M
MBP-03-B-M MBP-06-B-M MBA-01-B-H MBA-02-B-H MBA-03-B-H MBA-06-B-H
MBA-01-B-M MBA-02-B-M MBA-03-B-M MBA-06-B-M MBB-01-B-H MBB-02-B-H
MBB-03-B-H MBB-06-B-H MBB-01-B-M MBB-02-B-M MBB-03-B-M MBB-06-B-M
MBW-01-B-H MBW-02-B-H MBW-03-B-H MBW-01-B-M MBW-02-B-M MBW-03-B-M
MBP-01-C-H MBP-02-C-H MBP-03-C-H MBP-06-C-H MBP-01-C-M MBP-02-C-M
MBP-03-C-M MBP-06-C-M MBA-01-C-H MBA-02-C-H MBA-03-C-H MBA-06-C-H
MBA-01-C-M MBA-02-C-M MBA-03-C-M MBA-06-C-M MBB-01-C-H MBB-02-C-H
MBB-03-C-H MBB-06-C-H MBB-01-C-M MBB-02-C-M MBB-03-C-M MBB-06-C-M
MBW-01-C-H MBW-02-C-H MBW-03-C-H MBW-01-C-M MBW-02-C-M MBW-03-C-M
MBP-01-H-H MBP-02-H-H MBP-03-H-H MBP-06-H-H MBP-01-H-M MBP-02-H-M
MBP-03-H-M MBP-06-H-M MBA-01-H-H MBA-02-H-H MBA-03-H-H MBA-06-H-H
MBA-01-H-M MBA-02-H-M MBA-03-H-M MBA-06-H-M MBB-01-H-H MBB-02-H-H
标准型油路块
MMCA-02-3 MMCA-03-3 MMCB-02-3 MMCB-03-3 梭动阀SHT-02
直入式溢流插装阀
CVB-M-50-6-H-D4-A25 CVB-M-40-6-H-D5-A25
CVB-M-16-6-H-D4-A25 CVB-M-25-6-H-D4-A25 CVB-M-32-6-H-D4-A25 CVB-M-40-6-H-D4-A25
CVB-M-16-6-H-D5-A25 CVB-M-25-6-H-D5-A25 CVB-M-32-6-H-D5-A25 CVB-M-40-6-H-D5-A25
电磁换向阀
D5-02-3C2,D5-02-2B2,D5-02-3,D5-02-3C60,D5-02-2D2,
D5-03-3C2,D5-03-2B2,D5-03-3,D5-03-3C60,D5-03-2D2.
D4-02-3C2,D4-02-2B2,D4-02-3,D4-02-3C60,D4-02-2D2,
D4-03-3C2,D4-03-2B2,D4-03-3,D4-03-3C60,D4-03-2D2.
D5-02-2B2B D5-02-2B3B D5-02-2B4B D5-02-2B5B D5-02-2B40B D5-02-2B60B
D5-02-2B2-A25 D5-02-2B2-A15 D5-02-2B2-A35 D5-02-2B2-D1 D5-02-2B2-D2
D5-02-2B3-A25 D5-02-2B3-A15 D5-02-2B3-A35 D5-02-2B3-D1 D5-02-2B3-D2
D5-02-2B8-A25 D5-02-2B8-A15 D5-02-2B8-A35 D5-02-2B8-D1 D5-02-2B8-D2
卸荷溢流阀
BUCG-06-B-G BUCG-06-C-G BUCG-06-H-G
DB系列先导式溢流阀
DB-03-1 DB-03-3 DB-06-1 DB-06-3 DB-10-1 DB-10-3
管式单向节流阀
TVC-02 TVC-03 TVC-04 TVC-06 TVL-03 TVH-03 TVH-04
电磁控制调速阀
THF-06 THF-10 SF-06 SF-10 SDF-06 SDF-10 SFD-10 SD-06 SKF-06
加强型先导式溢流阀
BHG-06-B-G BHG-06-C-G BHG-06-H-G BHG-10-B-G BHG-10-C-G BHG-10-H-G
VOP润滑泵
VOP-203-A2-F-RV VOP-204-A2-F-RV VOP-206-A2-F-RV VOP-208-A2-F-RV VOP-210-A2-F-RV
VOP-212-A2-F-RV VOP-216-A2-F-RV VOP-220-A2-F-RV
HV-03-0-3C2 CPD-03-A1-T-D CPD-04-A1-T-D CPD-06-A1-T-D CPD-10-A1-T-D CPD-16-A1-T-D
机械式换向阀
DCG-02-NC-A DCG-02-NC-B DCG-02-NC-C DCG-02-NO-A DCG-02-NO-B DCG-02-NO-C
DCT-02-NC-A DCT-02-NC-B DCT-02-NC-C DCT-02-NO-A DCT-02-NO-B DCT-02-NO-C

压力继电器部分型号：
JCD-02S JCS-02N JCS-02NL JCS-02NLL
JPS-02HM JPS-02L JPS-02LL
MJCS-02P-N MJCS-02A-N MJCS-02B-N MJCS-02W-N MJCS-02-P-L MJCS-02-A-L MJCS-02-B-L
MJCS-02-W-L MJCS-02P-LL MJCS-02A-LL 

APSA-150-1 APSA-150-2 APSA-150-3 APSA-150-4 APSA-230-1 APSA-230-2 APSA-230-3
APSA-230-4 APSA-35-1 APSA-35-2 APSA-35-3 APSA-35-4 APSA-420-1 APSA-420-2 APSA-420-3
APSA-420-4 APSA-70-1 APSA-70-2 APSA-70-3 APSA-70-4 APSB-150-1
APSB-150-2 APSB-150-3 APSB-150-4 APSB-230-1 APSB-230-2 APSB-230-3 APSB-230-4 APSB-35-1
APSB-35-2 APSB-35-3 APSB-35-4 APSB-420-1 APSB-420-2 APSB-420-3 APSB-420-4 APSB-70-1
APSB-70-2 APSB-70-3 APSB-70-4 APSC-125-1
APSC-125-2 APSC-125-3 APSC-125-4 APSC-275-1 APSC-275-2 APSC-275-3 APSC-275-4
APSC-400-1 APSC-400-2 APSC-400-3 APSC-400-4 APSC-60-1 APSC-60-2 APSC-60-3 APSC-60-4
APSD-40-1 APSD-40-2 APSD-40-3 APSD-40-4
APSE-125-1 APSE-125-2 APSE-125-3 APSE-125-4 APSE-275-1 APSE-275-2 APSE-275-3
APSE-275-4 APSE-400-1 APSE-400-2 APSE-400-3 APSE-400-4 APSE-60-1 APSE-60-2 APSE-60-3 APSE-60-4
APSF-125-1 APSF-125-2 APSF-125-3 APSF-125-4 APSF-275-1 APSF-275-2 APSF-275-3 APSF-275-4
APSF-400-1 APSF-400-2 APSF-400-3 APSF-400-4 APSF-60-1 APSF-60-2 APSF-60-3 APSF-60-4
APSG-125-1 APSG-125-2 APSG-125-3 APSG-125-4 APSG-275-1 APSG-275-2 APSG-275-3 APSG-275-4
APSG-60-1 APSG-60-2 APSG-60-3 APSG-60-4
APSH-125-1 APSH-125-2 APSH-125-3 APSH-125-4 APSH-275-1 APSH-275-2 APSH-275-3
APSH-275-4 APSH-60-1 APSH-60-2 APSH-60-3 APSH-60-4